Product ID:NEW TONER FOR ACTION LASER 1000/1500
MSDS Date:09/21/1992
FSC:6850
NIIN:00N055017
MSDS Number: CBVWL

MINOLTA CAMERA CO LTD

3-13, 2-CHOME AZUCHI-MACH, CHUO-KU
OSAKA 541, JAPAN

Emergency Phone: 06-271-2251

Info Phone: 06-271-2251

Cage: S4049

MINOLTA CAMERA CO LTD

HIGASHI-KU OSAKA 541

Telephone: 05-271-2251

Cage: S4049

POLYESTER RESIN

Fraction By Weight: >85%

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 1-5%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

ORGANIC PIGMENT

CAS: 32517-36-5

Fraction By Weight: 1-3%

OSHA PEL N/K

ACGIH TLV: N/K

PROPENE, POLYMERS; (POLYPROPYLENE)

CAS: 9003-07-4

RTECS: UD1842000

Fraction By Weight: 1-3%

OSHA PEL N/K

ACGIH TLV: N/K

SILICA GEL; (AMORPHOUS SILICA)

CAS: 112945-52-5

RTECS: VV7310000

Fraction By Weight: <1%

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

LD50 LC50 Mixture:LD50:(ORAL,RAT) >5 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MIN RESP TRACT IRRIT MAY OCCUR
AS W/EXPOS TO LG AMTS OF ANY NONTOXIC DUST. MAY CAUSE COUGH & RAISE
PHLEGM. TONER REPRESENTS LOW HAZ FOR USUAL OCCUP SETTINGS. BASED ON
AVAIL DATA, HUMAN EXPOS TO TONER HAS BEEN SHOWN TO CAUSE MIN RESP
TRACT IRRIT AS MAY OCCUR W/LG AMTS OF ANY NON-TOX DUSTS. THE (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:RSLTS OF ONE ANIMAL STUDY WHERE RATS
INHALED TONER THAT WAS 10 TIMES MORE RESPIRABLE THAN COMMERCIALLY
AVAIL TONER WERE OBSERVED TO HAVE NO LUNG CHANGES AT LOW EXPOS
(MOST RELEVANT LEVEL TO P OTNTL HUMAN EXPOS). AT HIGHER LEVELS A
SLIGHT DEGREE OF LUNG FIBROSIS WAS OBSERVED DUE TO EXCESSIVE AMTS
OF DUST(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:WASH NOSTRILS, RINSE MOUTH. INGEST:DILUTE STOMACH
CONTENTS W/SEVERAL GLASSES OF WATER. EYES:FLUSH W/WATER FOR AT
LEAST 15 MINUTES. SKIN:WASH W/SOAP & WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:IF DISPERSED IN AIR, TONER, LIKE MOST
FINELY DIVIDED ORGANIC POWDERS, MAY FORM AN EXPLOSIVE MIXTURE.

Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:TONER, AS A MIXTURE, IS CONSIDERED AS NUISANCE DUST.

Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED WHEN USED AS INTENDED IN
MINOLTA EQUIPMENT.
Protective Gloves:NONE REQD WHEN USED AS INTENDED (SUPDAT)
Eye Protection:ANSI APPROVED SAFETY GLASSES .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE.
Supplemental Safety and Health
EFTS OF OVEREXP:RETAINED IN THE LUNGS FOR A PROLONGED INTERVAL. PROT
GLOVES:IN MINOLTA EQUIPMENT.

Spec Gravity:1.2 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER; FAINT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:WASTE MAY BE DISPOSED OR INCINERATED UNDER
CONDITIONS WHICH MEET ALL FEDERAL, STATE & LOCAL ENVIRONMENTAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.